PENETRATING OIL_Bulk_English
Safety Data Sheet Regulation EC No 1907/2006 Art.31
Productname : PENETRATING OIL Creationdate : 17.07.17 Version : 3.0
Ref.Nr.: BDS000938_3_20170717 (EN) Replaces: BDS000938_20131217
 
SECTION 1: Identification of the substance/mixture and of the company/undertaking
 
1.1. Product identifier
 
 
PENETRATING OIL
Bulk
 
1.2. Relevant identified uses of the substance or mixture and uses advised against
 
Lubricants
 
1.3. Details of the supplier of the safety data sheet
 
 
CRC Industries Europe bvba
Touwslagerstraat 1
9240 Zele
Belgium
Tel.: +32(0)52/45.60.11
Fax.: +32(0)52/45.00.34
E-mail : hse@crcind.com
 
SubsidiariesTelFax
CRC Industries Finland OyLaurinkatu 57 A 23 B, 08100 Lohja+358/(19)32.921
CRC Industries France6, avenue du marais, C.S. 90028, 95102 Argenteuil Cedex01.34.11.20.0001.34.11.09.96
CRC Industries Deutschland GmbHSüdring 9, D-76473 Iffezheim(07229) 303 0(07229)30 32 66
CRC INDUSTRIES IBERIA S.L.U.GREMIO DEL CUERO-PARC.96, POLIGONO INDUSTR. DE HONTORIA, 40195 SEGOVIA0034/921.427.5460034/921.436.270
CRC Industries SwedenLaxfiskevägen 16, 433 38 Partille0046/31 706 84 800046/31 27 39 91
 
1.4. Emergency telephone number
 
 
CRC Industries Europe, Belgium: Tel.: +32(0)52/45.60.11 (office hours: 9-17h pm CET)
 
SECTION 2: Hazards identification
 
2.1. Classification of the substance or mixture
 
Classification according to Regulation (EC) No 1272/2008
 
Physical: Not classified
Classification is based on test data.
Health: Aspiration Hazard Category 1
 May be fatal if swallowed and enters airways.
Classification based on calculation method.
Environment: Not classified
Classification based on calculation method.
Other hazards : Repeated exposure may cause skin dryness or cracking.
Other hazards : Not classified
 
2.2. Label elements
 
Labelling according to Regulation (EC) No 1272/2008
 
Product identifier: Contains:
 hydrocarbons
Hazard pictogram(s):      
Signal word: Danger
Hazard statement(s): H304 : May be fatal if swallowed and enters airways.
Precautionary statement(s): P102 : Keep out of reach of children.
P301/310 : IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician.
 P331 : Do NOT induce vomiting.
P405 : Store locked up.
P501-2 : Dispose of contents/container to an authorised waste collection point.
Supplemental Hazard information: Repeated exposure may cause skin dryness or cracking.
 
2.3. Other hazards
 
No information available
 
SECTION 3: Composition/information on ingredients
 
3.1. Substances
 
Not applicable.
 
3.2. Mixtures
 
 
Hazardous ingredientRegistration numberCAS-nr.EC-nrw/w %Hazard Class and CategoryHazard statementNotes
Hydrocarbons, C11-C14, n-alkanes, isoalkanes, cyclics, < 2% aromatics01-2119456620-43-(926-141-6)60-100Asp. Tox. 1H304B,Q
mineral oil (IP 346 DMSO extract < 3%)---10-30--B
sulfonic acids,petroleum,sodium salts01-2119527859-2268608-26-4271-781-51-5Skin Irrit. 2, Eye Irrit. 2H315,H319
Explanation notes
B : substance with national established workplace exposure limit
Q : The CAS-no is only an indicative identifier to be used outside the EU for global inventory entries.
(* Explanation phrases : see chapter 16)
 
SECTION 4: First aid measures
 
4.1. Description of first aid measures
 
Contact with eyes : If substance has got into eyes, immediately wash out with plenty of water for several minutes
 Seek medical attention if irritation persists
Contact with skin : Wash with water and soap.
 Seek medical attention if irritation persists
Inhalation : IF INHALED: Remove person to fresh air and keep comfortable for breathing.
 Call a POISON CENTER or doctor/physician if you feel unwell.
Ingestion : IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician.
 Do NOT induce vomiting.
 
4.2. Most important symptoms and effects, both acute and delayed
 
Inhalation : Excessive inhalation of solvent vapours may give rise to nausea, headaches and dizziness
Ingestion : After vomiting of swallowed product aspiration into lungs is likely. Solvents may induce chemical pneumonia.
 Symptoms : sore throat, abdominal pain, nausea, vomiting
Skin contact : Mildly irritating to skin
 Symptoms : redness and pain
Eye contact : Mildly irritating to eyes
 Symptoms : redness and pain
 
4.3. Indication of any immediate medical attention and special treatment needed
 
General Advice : If you feel unwell, seek medical advice (show the label where possible
 If symptoms persist always call a doctor
 
SECTION 5: Firefighting measures
 
5.1. Extinguishing media
 
foam, carbon dioxide or dry agent
 
5.2. Special hazards arising from the substance or mixture
 
May form explosive vapour/air mixtures
Forms hazardous decomposition products
CO,CO2
 
5.3. Advice for firefighters
 
Keep container(s) exposed to fire cool, by spraying with water
In case of fire, do not breathe fumes
 
SECTION 6: Accidental release measures
 
6.1. Personal precautions, protective equipment and emergency procedures
 
Shut off all ignition sources
Ensure adequate ventilation
Wear suitable protective clothing including eye/face protection.
Ground/bond container and receiving equipment.
Use explosion-proof electrical/ventilating/lighting/.../equipment.
 
6.2. Environmental precautions
 
Do not allow to enter public sewers and watercourses
 
6.3. Methods and material for containment and cleaning up
 
Absorb spillage in suitable inert material
 
6.4. Reference to other sections
 
For further information see section 8
 
SECTION 7: Handling and storage
 
7.1. Precautions for safe handling
 
Keep away from heat and sources of ignition
Take precautionary measures against static discharges
Equipment should be earthed
Use explosion-proof electrical/ventilating/lighting/.../equipment.
Use only non-sparking tools.
Do not breathe aerosols or vapours.
Ensure adequate ventilation
Avoid contact with skin and eyes.
Wash thoroughly after use
Wear protective gloves/protective clothing/eye protection/face protection.
 
7.2. Conditions for safe storage, including any incompatibilities
 
Keep container tightly closed, in a cool, well ventilated place.
Keep out of reach of children.
 
7.3. Specific end use(s)
 
Lubricants
 
SECTION 8: Exposure controls/personal protection
 
8.1. Control parameters
 
Exposure limits :
 
 
No information available
 
8.2. Exposure controls
 
Control procedures : Ensure adequate ventilation
Keep away from heat and sources of ignition
Take precautionary measures against static discharges
Personal protection : Take precautions to avoid contact with skin and eyes when handling the product.
 It is good practice to wear gloves and to provide adequate ventilation whenever using the product.
 In all cases handle and use the product in accordance with good industrial hygiene practices.
inhalation : In case of insufficient ventilation, wear suitable respiratory equipment.
recommended respiratory protection: Air purifying respirator equiped with organic gas/vapor cartridge (type A)
hands and skin : Wear suitable protective gloves against chemicals. Check the appropriateness of the recommended gloves for your own particular conditions of use and replace gloves regularly after check for signs of damage or defects.
Recommended gloves: Nitrile
eyes : Wear safety eyewear according to EN 166.
 
SECTION 9: Physical and chemical properties
 
9.1. Information on basic physical and chemical properties
 
Appearance : physical state : Liquid.
colour : Black.
odour : Characteristic odor.
pH : Not applicable.
Boiling point/range : Not available.
Flash point : 75 °C (Closed Cup)
Evaporation rate : Not available.
Explosion limits : upper limit : Not available.
lower limit : Not available.
Vapour pressure : Not available.
Relative density : 0.82 g/cm3 (@ 20°C).
Solubility in water : Insoluble in water
Auto-ignition : > 200 °C
Viscosity : Not available.
 
9.2. Other information
 
VOC = volatile organic compounds 815 g/l
 
SECTION 10: Stability and reactivity
 
10.1. Reactivity
 
No hazardous reactions known if used for its intended purpose
 
10.2. Chemical stability
 
Stable
 
10.3. Possibility of hazardous reactions
 
No hazardous reactions known if used for its intended purpose
 
10.4. Conditions to avoid
 
Avoid overheating
 
10.5. Incompatible materials
 
Strong oxidising agent
 
10.6. Hazardous decomposition products
 
CO,CO2
 
SECTION 11: Toxicological information
 
11.1. Information on toxicological effects
 
acute toxicity: based on available data the classification criteria are not met
skin corrosion/irritation: based on available data the classification criteria are not met
serious eye damage/irritation: based on available data the classification criteria are not met
respiratory or skin sensitisation: based on available data the classification criteria are not met
germ cell mutagenicity: based on available data the classification criteria are not met
carcinogenicity: based on available data the classification criteria are not met
toxicity for reproduction: based on available data the classification criteria are not met
STOT-single exposure: based on available data the classification criteria are not met
STOT repeated exposure: based on available data the classification criteria are not met
aspiration hazard: May be fatal if swallowed and enters airways.
 
Information on likely routes of exposure:
 
Inhalation : Inhalation of solvent vapours may give rise to nausea, headaches and dizziness
Ingestion : After vomiting of swallowed product aspiration into lungs is likely. Solvents may induce chemical pneumonia.
Skin contact : Prolonged skin contact will result in defatting of the skin, leading to irritation, and in some cases, dermatitis
Eye contact : May cause irritation.
 
Toxicological data :
 
 
Hazardous ingredientCAS-nr.method
Hydrocarbons, C11-C14, n-alkanes, isoalkanes, cyclics, < 2% aromatics-LD50 oral rat> 5000 mg/kg
LC50 inhal.rat>5000 mg/kg
LD50 derm.rabit> 5000 mg/kg
 
SECTION 12: Ecological information
 
12.1. Toxicity
 
Not classified
 
Ecotoxicological data:
 
 
Hazardous ingredientCAS-nr.method
Hydrocarbons, C11-C14, n-alkanes, isoalkanes, cyclics, < 2% aromatics-IC50 algae1000 mg/l
LC50 fish1000 mg/l
EC50 daphnia1000 mg/l
 
12.2. Persistence and degradability
 
No experimental data available
 
12.3. Bioaccumulative potential
 
No experimental data available
 
12.4. Mobility in soil
 
Insoluble in water
 
12.5. Results of PBT and vPvB assessment
 
No information available
 
12.6. Endocrine disrupting properties
 
No experimental data available
 
SECTION 13: Disposal considerations
 
13.1. Waste treatment methods
 
Product : This material and its container must be disposed of in a safe way.
Do not discharge into drains or the environment, dispose to an authorised waste collection point.
Contaminated packaging : Disposal should be in accordance with local, state or national legislation
 
SECTION 14: Transport information
 
14.1. UN number
 
UN-number : Not classified as hazardous for transport
 
14.2. UN proper shipping name
 
Proper shipping name: Not applicable.
 
14.3. Transport hazard class(es)
 
Class: Not applicable.
ADR/RID - Classification code: Not applicable.
 
14.4. Packing group
 
Packing group: Not applicable.
 
14.5. Environmental hazards
 
ADR/RID - Environmentally hazardous: No
IMDG - Marine pollutant: No
IATA/ICAO - Environmentally hazardous: No
 
14.6. Special precautions for user
 
ADR/RID - Tunnelcode: Not applicable.
IMDG - Ems: Not applicable.
IATA/ICAO - PAX: Not applicable.
IATA/ICAO - CAO Not applicable.
 
14.7. Maritime transport in bulk according to IMO instruments
 
Not applicable.
 
SECTION 15: Regulatory information
 
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
 
The Safety Data Sheet is compiled according to the current European requirements.
Regulation (EC) No 1907/2006 (REACH)
Regulation (EC) No 1272/2008 (CLP)
 
15.2. Chemical safety assessment
 
No information available
 
SECTION 16: Other information
 
*Explanation hazard statements: - : -
 H304 : May be fatal if swallowed and enters airways.
 H315 : Causes skin irritation.
 H319 : Causes serious eye irritation.
REVISIONS IN CHAPTRE : 8.2. Exposure controls
acronyms and synonyms: TWA = time weight average
 STEL = short time exposure limit
 VOC = volatile organic compounds
 PBT = persistant bioaccumulative toxic
 vPvB = very persitant very bioaccumulative
This product should be stored, handled and used in accordance with good industrial hygiene practices and in conformity with any legal regulation.
The information contained herewith is based on the present state of our knowledge and is intended to describe our products from the point of view of safety requirements. It does not guarantee any specific properties.
Apart from any fair dealing for purposes of study, research and review of health, safety and environmental risks,no part of these documents may be reproduced by any process without written permission from CRC.